thejoe Volvo Vnl

Volvo Vnl recalls

27 recall campaigns, model years 2015 to 2023. Each lists the fault, the risk, and the fix you are owed.

27Campaigns

2015–2023Years affected

1Do-not-drive

Do not drive

NHTSA flags 1 of these as park-it recalls. Stop driving it. Get the repair done first. Call a dealer now.

Check your own car in one step

Your VIN is on the dashboard by the windscreen. It is on your insurance card too. Put it into nhtsa.gov/recalls. You get the open recalls for your exact car. The repair is free. Most recalls never expire.

What keeps failing

System	Campaigns
Service Brakes, Air	5
Power Train	5
Engine And Engine Cooling	4
Electrical System	3
Suspension	2
Parking Brake	2
Steering	2
Structure	2

Every campaign

The text below is quoted from NHTSA word for word.

Steering

17V536000 · reported 29/08/2017

The fault: Volvo Trucks North America (Volvo) is recalling certain 2016 Volvo VNL and VNM trucks equipped with certain Dana Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
What it can cause: If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering, increasing the risk of a crash.
The fix: Volvo will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on October 17, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1702.

Engine And Engine Cooling:engine:diesel

18V668000 · reported 25/09/2018

The fault: Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
What it can cause: If the fuel line bursts, fuel may leak onto the road resulting in a roadway hazard for other motorists. The engine may also stall without warning, resulting in the vehicle's inability to restart, increasing the risk of a crash.
The fix: Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1802.

Visibility:windshield Wiper/washer:motor

23V511000 · reported 24/07/2023

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2024 VNR, VNL, VHD, and VAH trucks. The windshield wiper motor gears may wear prematurely, causing the motor to fail.
What it can cause: Inoperative windshield wipers can reduce visibility, increasing the risk of a crash.
The fix: Dealers will replace the windshield wiper motor assembly, free of charge. Owner notification letters were mailed November 1, 2023. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks number for this recall is RVXX2309.

Engine And Engine Cooling:engine

14V139000 · reported 24/03/2014

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2013-2015 VNL trucks, and 2013-2014 VNM trucks equipped with certain Cummins Westport Model ISL G and ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
What it can cause: The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
The fix: Cummins Inc. and Cummins Wesport Inc. will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Owners may contact Volvo at 1-800-528-6586. Volvo's number for this recall is RVXX1401.

Service Brakes, Air

16V928000 · reported 22/12/2016

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
What it can cause: If the brake system becomes contaminated, braking performance could be affected, increasing the risk of a crash.
The fix: Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1608.

Parking Brake:driveline:hydraulic:actuator

15V026000 · reported 22/01/2015

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2015 and 2016 VNX and VNL trucks manufactured from May 20, 2014, through March 6, 2015, equipped with certain Haldex Life Seal Type 30/30 Long Stroke Air Brake Actuators manufactured January 9, 2014, to October 28, 2014. The affected actuators may have an incomplete attachment of the internal rubber diaphragm to the actuation mechanism of the parking brake section of the Life Seal actuator.
What it can cause: If the diaphragm is not completely attached, there may be internal leakage from the service section past the diaphragm, potentially trapping air pressure in the parking brake section. This air pressure in turn, if not vented, may prevent full release of the actuator unit, and may induce brake drag and may result in overheated wheelend service brakes, increasing the risk of a fire.
The fix: Volvo will notify owners, and dealers will inspect the brake actuator and replace, as necessary, free of charge. The recall began March 20, 2015. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1501.

Suspension:front

19V617000 · reported 21/08/2019

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2015 VNL vehicles equipped with Meritor FF967 Non-Drive Front Steer axles. The axles missed the heat treating operation during manufacturing, reducing their strength and possibly causing the axle beams to fracture.
What it can cause: Fracture of the axle beam can cause a loss of vehicle control, increasing the risk of a crash.
The fix: Volvo Trucks will notify the affected vehicle owners, and dealers will inspect and replace the axles as necessary, free of charge. The recall began September 27, 2019. Owners may contact Meritor customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX1905.

Forward Collision Avoidance: Adaptive Cruise Control

14V356000 · reported 20/06/2014

The fault: Volvo Trucks of North America (Volvo) is recalling certain model year 2011-2015 VNL and 2014-2015 VNM trucks manufactured November 17, 2010, through February 5, 2014, and equipped with enhanced cruise control and without side fairings. In the affected vehicles, the active braking component of the enhanced cruise control can become disabled.
What it can cause: If the active braking feature becomes disabled, the vehicle may not automatically activate the brakes as intended when the enhanced cruise control system is in use, thereby increasing the risk of a crash.
The fix: Volvo will notify owners, and dealers will update the control unit software, free of charge. The recall began on August 12, 2014. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1402.

Wheels

21V098000 · reported 19/02/2021

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2022 VNL vehicles equipped with Alcoa Mirror Polish Wheels, part number ULT 391, and wheel size 22.5 x 8.25. Under certain circumstances, these wheels may not be able to support the load, which can cause the wheels to bend or break while in use.
What it can cause: Bent or broken wheels can increase the risk of a crash.
The fix: The affected vehicles have been contained by the manufacturer, and therefore no owners will be notified. Dealers will replace the wheels, free of charge. The recall began January 29, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks number for this recall is 21E-007.

Suspension:front:control Arm:upper Ball Joint

16V095000 · reported 19/02/2016

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2009-2010 VT trucks manufactured from April 9, 2008, through September 24, 2009, and certain 2016 model VNL and VNM trucks manufactured from January 2, 2015, through to November 6, 2015. The affected vehicles are equipped with USK non-greasable drag links that may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
What it can cause: Failure of the ball joint may cause separation of the socket and a complete loss of steering, increasing the risk of a crash.
The fix: Volvo will notify owners, and dealers will replace the drag links, free of charge. The recall began on April 21, 2016. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1601. Note: This recall is an expansion of a previous recall 15V-651.

Power Train:automatic Transmission

14V739000 · reported 18/11/2014

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2012, 2014-2015 VHD, 2012-2015 VNL, and 2014-2015 VNM trucks manufactured June 16, 2011, to August 18, 2014, and equipped with the Eco-Roll option. The affected trucks may fail to re-engage the vehicle drivetrain after using the Eco-Roll feature.
What it can cause: If the drivetrain does not re-engage, the vehicle's stopping distance may be lengthened, increasing the risk of a crash.
The fix: Volvo has notified owners, and dealers will update the Eco-Roll software, free of charge. The recall began on December 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1406.

Structure:body

19V208000 · reported 18/03/2019

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VNL and VNX vehicles configured as 740 and 760 sleeper models. The sleeper bunk window may detach and fall from the vehicle.
What it can cause: If a window detaches from the vehicle, it may strike another vehicle or pedestrian, increasing the risk of a crash or injury.
The fix: Volvo Trucks has notified owners, and dealers will replace the window hinge, free of charge. Owners were notified of the recall on April 8, 2019 and will be sent a second notice when the remedy parts are available. The recall began August 21, 2019. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX1902.

Service Brakes

15V524000 · reported 17/08/2015

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2012-2015 VNL and VNM trucks manufactured May 31, 2011, to December 1, 2014. In the affected trucks, the trailer hand brake handle may not to return to the off position due to being restricted by the cut out in the trim panel.
What it can cause: If the brake handle does return to the off position, the trailer service brakes may drag causing the wheel end to overheat and potentially cause a wheel end fire or tire blowout. Either condition increases the risk of a crash.
The fix: Volvo will notify owners, and dealers will inspect the trim panel slot and make it longer, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Volvo customer service at 1-800-258-6586. Volvo's number for this recall is RVXX1504.

Do not drive

Steering

16V097000 · reported 17/02/2016

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2016-2017 VNL, VNX, and VNM trucks manufactured from May 11, 2015, through April 18, 2016. The trucks may have been manufactured without a roll pin on the steering shafts. If the roll pin is missing, the lower steering shaft may disconnect from the junction block. Also, the bolt connecting the upper steering shaft to the lower steering shaft may not have been properly tightened. Either condition can lead to separation of the steering shaft.
What it can cause: Separation of the steering shaft will result in complete loss of steering which may lead to a vehicle crash.
The fix: Volvo is strongly recommending that the affected vehicles not be driven until the interim remedy is applied. An interim notice was sent to Volvo owners on March 16, 2016, and an interim repair is available now. A second notice was mailed on May 13, 2016. The final remedy is now available. Both remedies are free of charge. Owners may contact Volvo customer service at 1-877-800-4945 opt #1. Volvo's recall numbers for this campaign are RVXX1602 and RVXX1603. This recall supersedes safety recall 15V-786.

Trailer Hitches:fifth Wheel Assembly

18V542000 · reported 16/08/2018

The fault: Volvo Trucks North America (Volvo) is recalling certain 2019 Volvo VNL and VNR trucks equipped with Jost fifth wheel couplings. The fifth wheel may have an outboard slider bracket that is too narrow, possibly allowing the trailer to separate from the tractor.
What it can cause: If the trailer separates from the tractor, it can increase the risk of a crash.
The fix: Volvo will notify owners, and dealers will inspect the fifth wheel slider bracket, replacing it as necessary, free of charge. The recall began September 25, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall RVXX1801.

Tires

18V811000 · reported 15/11/2018

The fault: Volvo Trucks North America (Volvo) is recalling certain 2019 Volvo VNL and VHD trucks, equipped with Bridgestone M854 tires with date codes 2418-2518, Bridgestone M860A tires with date code 2518, and Bridgestone M864 tires with date codes 2318-2418, all of size 425/65R22.5. The sidewall steel body cords may be exposed, possibly causing unexpected, rapid air loss during use. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 119, "New Pneumatic Tires - Other than Passenger Cars."
What it can cause: Rapid tire air loss can increase the risk of a crash.
The fix: Volvo will notify owners, instructing them to take their vehicles to Bridgestone Tire or Volvo Truck service centers for inspection and replacement, as necessary, free of charge. The recall began December 19, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1803.

Power Train:clutch Assembly

19V032000 · reported 14/01/2019

The fault: Volvo Trucks North America (Volvo) is recalling certain 2018-2019 Volvo VNL vehicles equipped with an automated manual transmission. An internal component in the clutch assembly may fail, possibly resulting in unintended vehicle movement.
What it can cause: Unintended vehicle movement can increase the risk of a crash.
The fix: Volvo has notified owners and dealers will update the Transmission Control Module software, free of charge. The recall began February 1, 2019. Owners can contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1901.

Electrical System:software

14V557000 · reported 11/09/2014

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2015 VNL and VNX trucks manufactured January 7, 2014, to June 5, 2014, and equipped with a D16 engine. Due to the engine control unit having an incorrect parameter setting in the software, the engine may stall.
What it can cause: An engine stall while driving increases the risk of a crash.
The fix: Volvo will notify owners, and dealers will update the engine control unit software, free of charge. The recall began in October 2014. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1404.

Service Brakes, Air:disc:caliper

14V555000 · reported 11/09/2014

The fault: Volvo Trucks North America (Volvo) is recalling certain model year 2014-2015 VAH, VNL, and VNM trucks manufactured March 4, 2013, to April 28, 2014. Due to the bolts holding the disc brake caliper to the backing plate not being tightened to the specified torque, the disc brake caliper may detach from the backing plate.
What it can cause: If the disc brake caliper detaches from the backing plate it can affect the brakes to that particular wheel causing the vehicle to "pull" to the left or right, increasing the risk of a crash.
The fix: Volvo will notify owners, and dealers will inspect and tighten the bolts to specification, as necessary, free of charge. The recall began October 10, 2014. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1403.

Engine

21V065000 · reported 11/02/2021

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2022 VNL vehicles equipped with Cummins X15 diesel engines. The capscrews that attach the flywheel to the crankshaft may have been improperly torqued, allowing the flywheel to detach.
What it can cause: A detached flywheel can cause loss of drive power, increasing the risk of a crash. Additionally, driveline pieces may be ejected from the engine compartment, increasing the risk of injury.
The fix: The affected vehicles are still within the manufacturer's control. The Volvo Trucks manufacturing facility will properly torque the capscrews and inspect for possible damage and, if necessary, repair any damage found, free of charge. The recall began January 5, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586.

Service Brakes, Air:supply:reservoir/tank

22V896000 · reported 06/12/2022

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2022-2023 VNL vehicles. The air tank bracket fasteners were excessively tightened and may have broken.
What it can cause: Broken fasteners may allow the air tank to detach from the vehicle, becoming a road hazard and increasing the risk of a crash.
The fix: Dealers will replace the fasteners, free of charge. Owner notification letters were mailed December 16, 2022. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2205.

Power Train:automatic Transmission

21V781000 · reported 06/10/2021

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2022 VNL vehicles. The electronic control unit software may allow the transmission to shift into neutral unexpectedly.
What it can cause: An unexpected shift to neutral can increase the risk of a crash.
The fix: Dealers will reprogram the electronic control module, free of charge. Owner notification letters were mailed on November 01, 2021. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2104.

Air Bags:side/window:curtain

23V403000 · reported 04/06/2023

The fault: Volvo Trucks North America (Volvo Truck) is recalling certain 2022-2024 VNL and VHD vehicles equipped with RollTek driver seats. A missing circuit will prevent the side air bag from deploying during a crash.
What it can cause: An air bag that does not deploy, increases the risk of an injury.
The fix: Dealers will connect a jumper harness between the seat and main cab harness, free of charge. Owner notification letters are expected to be mailed August 4, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2305.

Electrical System:wiring:fuses And Circuit Breakers

19V509000 · reported 02/07/2019

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2018-2020 VAH, VHD, VNL, and VNR vehicles. The fuse in the transmission circuit may blow, preventing the transmission from shifting.
What it can cause: If the fuse blows the transmission may not shift, increasing the risk of a crash.
The fix: Volvo Trucks will notify owners, and dealers will inspect and replace the fuse, if necessary, free of charge. The recall began August 7, 2019. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Truck's number for this recall is RVXX1903.

Power Train:automatic Transmission

19V510000 · reported 02/07/2019

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2020 VAH, VHD, VNL, and VNR vehicles. The t-bolt clasps on the transmission auxiliary air tank straps may have been over-tightened, resulting in potential deformation to the strap where the t-bolt is anchored.
What it can cause: The deformation of the air tank strap t-bolts may cause the t-bolt to disconnect from the strap allowing the tank to drop to the ground and become a road hazard, increasing the risk of a crash.
The fix: Volvo Trucks will notify owners, and dealers will inspect and replace the air tank strap, if necessary, free of charge. The recall began August 7, 2019. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Truck's number for this recall is RVXX1904.

Wheels:hub

21V417000 · reported 02/06/2021

The fault: Volvo Trucks North America (Volvo Trucks) is recalling certain 2021-2022 VAH, VDH, VNL, AND VNR vehicles. The hubcap compression spring can cause the hubcap to separate.
What it can cause: A separated hubcap can create a road hazard, increasing the risk of a crash.
The fix: Dealers will remove the hubcap, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Mack's number for this recall is RVXX 2102.

Equipment:other:labels

20V384000 · reported 01/07/2020

The fault: Volvo Trucks North America (Volvo) is recalling certain 2018-2021 VNL and VNR buses. The Gross Axle Weight Rating (GAWR) for the rear drive axles stated on the Federal Certification Label exceeds the rating of the wheel hubs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
What it can cause: If the rear axles are overloaded, over time the wheel hubs may fail prematurely, increasing the risk of a crash.
The fix: Volvo will notify owners and send corrected replacement labels, free of charge. The recall began August 18, 2020. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX2002.

Source: NHTSA recalls API, retrieved 4 August 2026.

← All Volvo models